苝四甲酸标记PVA荧光浆料的制备及其性能

doi:10.19398/j.att.202201032

现代纺织技术 ›› 2022, Vol. 30 ›› Issue (5): 174-180.DOI: 10.19398/j.att.202201032

苝四甲酸标记PVA荧光浆料的制备及其性能

龙柱¹, 李曼丽^1,2,3, 陆浩杰⁴, 周赳⁴, 王益峰²

1.江南大学纺织科学与工程学院,江苏无锡 214122;
2.浙江富润数字科技股份有限公司,浙江诸暨 311800;
3.绍兴文理学院浙江省清洁染整技术研究重点实验室,浙江绍兴 312000;
4.浙江理工大学纺织科学与工程学院,杭州 310018

收稿日期:2022-01-26 出版日期:2022-09-10 网络出版日期:2022-09-19
通讯作者:李曼丽,E-mail:jdkxxh_2015@163.com
作者简介:龙柱(1966-),男,湖南新晃人,博士,教授,主要从事功能性纺织、造纸用化学品制备方面的研究。
基金资助:
浙江省公益性技术应用研究计划项目(LGG21E030005;LGG22E030002),浙江省清洁染整技术研究重点实验室开放基金项目(QJRZ1902),浙江省博士后科研择优资助项目(276089)

Preparation of fluorescent PTCA labeled PVA size and its properties

LONG Zhu¹, LI Manli^1,2,3, LU Haojie⁴, ZHOU Jiu⁴, WANG Yifeng²

1. College of Textile Science and Engineering, Jiangnan University, Wuxi 214122, China;
2. Zhejiang Furun Digital Technology Co., Ltd., Zhuji 311800, China;
3. Key Laboratory of Clean Dyeing and Finishing Technology of Zhejiang Province, Shaoxing University, Shaoxing 312000, China;
4. College of Textile Science and Engineering, Zhejiang Sci-Tech University, Hangzhou 310018, China

Received:2022-01-26 Published:2022-09-10 Online:2022-09-19

摘要/Abstract

摘要： 为解决目前纺织业中浆液浸透性与被覆性测定方法精准度低、品种适应性差等问题,以聚乙烯醇(PVA)为常用浆料代表,采用不同质量浓度的荧光分子3,4,9,10-苝四甲酸(PTCA)对PVA进行标记,制备出具有不同标记率的PVA荧光浆料并将其对纯棉经纱进行上浆。在制作成浆纱切片后,以荧光显微镜及Photoshop软件为工具,测定出切片横截面各组成部分面积,推算获取PVA浆液对纱线的浸透率和被覆率,同时对比测试了PTCA-PVA与未标记PVA浆纱的强伸、耐磨及毛羽贴服等主要使用性能。结果表明:当PTCA-PVA的标记率摩尔分数为0.0127%时,此改性PVA显示出良好的荧光性能。经PTCA-PVA上浆后,纱线的主要使用性能与未标记PVA所浆纱线的性能较为相近,选取PTCA对机织生产中的主要浆料进行荧光标记可为浆液对纱线浸透性与被覆性的评估提供一种准确度、普适度更高的研究方法。

关键词: 苝四甲酸, 聚乙烯醇, 荧光浆料, 浸透性, 被覆性

Abstract: Aiming at the solution to the problems of low accuracy and poor variety adaptability of the measurement method of the permeability and coating property of sizing paste to warp yarn in textile area at present, and taking polyvinyl alcohol (PVA) as the representative of common sizes, various concentrations of fluorescent molecule-3,4,9,10-perylene tetracarboxylic acid (PTCA) were used to label PVA to prepare PTCA-PVA fluorescent sizes with different degrees of labeling (DL) for the first time. Then the PVA sizes were employed to size pure cotton warp yarns. After preparing the sections of the sized yarns, the area of each component in the cross section was measured by using fluorescence microscope and Photoshop software. The permeability and coating percentage of PVA paste to the yarns were calculated. The main use performances such as breaking strength, wear resistance and yarn hairiness covering of PTCA-PVA and unlabeled PVA sizing were compared and tested. The results show that the PTCA-PVA with an appropriate DL (i.e. 0.0127 mol percent) exhibits good fluorescence property and very similar sizing performance to that of unlabeled PVA. It is considered that fluorescence labeling of main sizing agents used in weaving procedure with PTCA can provide a more universal and accurate way for the determination of the permeability and coating property of the sizing paste to warp yarns.

Key words: PTCA, PVA, fluorescent size, permeability, coating property

中图分类号:

TS103.846

龙柱, 李曼丽, 陆浩杰, 周赳, 王益峰. 苝四甲酸标记PVA荧光浆料的制备及其性能[J]. 现代纺织技术, 2022, 30(5): 174-180.

LONG Zhu, LI Manli, LU Haojie, ZHOU Jiu, WANG Yifeng. Preparation of fluorescent PTCA labeled PVA size and its properties[J]. Advanced Textile Technology, 2022, 30(5): 174-180.

参考文献

[1] LI W, WU L J, ZHU Z F, et al. Incorporation of poly(sodium allyl sulfonate) branches on corn starch chains for enhancing its sizing properties: Viscosity stability, adhesion, film properties and desizability[J]. International Journal of Biological Macromolecules, 2021, 166: 1460-1470.
[2] LI M L, JIN E Q, CHEN S Y. Effects of graft modification on apparent viscosity, adhesion, and film properties of sesbania gum for warp sizing[J]. Journal of the Textile Institute, 2020, 111: 309-317.
[3] 张慧晴,沈艳琴,武海良.脂肪醇聚氧乙烯醚在中温上浆中的应用研究[J].现代纺织技术,2019,27(4):81-83.
ZHANG Huiqing, SHEN Yanqin, WU Hailiang. Application of fatty alcohol polyoxyethylene ether in moderate temperature sizing[J]. Advanced Textile Technology, 2019, 27(4): 81-83.
[4] 范雪荣,荣瑞萍,纪惠军.纺织浆料检测技术[M].北京:中国纺织出版社,2007.
FAN Xuerong, RONG Ruiping, JI Huijun. Measurement Technique of Textile Sizes[M]. Beijing: China Textile & Apparel Press, 2007.
[5] SCHWARZ I G, KOVACEVIC S, DIMITROVSKI K. Analysis of changes in mechanical and deformation properties of yarn by sizing[J]. Textile Research Journal, 2011, 81(5): 545-555.
[6] JI C D, MA L, CHEN H T, et al. Perylene-based fluorescent nanoprobe for acid-enhanced detection of formaldehyde in lysosome[J]. ACS Applied Bio Materials, 2019, 2(1): 555-561.
[7] BAI S H, LIANG L L, WANG C L, et al. A novel glowing electrolyte based on perylene accompany with spectrum compensation function for efficient dye sensitized solar cells[J]. Journal of Power Sources, 2015, 280: 430-434.
[8] HAN A, LIU X H, PRESTWICH G D, et al. Fluorescent sensor for Hg²⁺ detection in aqueous solution[J]. Sensors and Actuators, B: Chemical, 2014, 198: 274-277.
[9] 张鲁燕,李曼丽,金恩琪.接枝改性对羽毛蛋白浆料浆纱性能的影响[J].纺织学报,2015,36(8):68-73.
ZHANG Luyan, LI Manli, JIN Enqi. Influence of graft modification on sizing properties of feather keratin[J]. Journal of Textile Research, 2015, 36(8): 68-73.
[10] 叶秋娟,李曼丽,金恩琪,等.丙烯酸酯单体结构对接枝淀粉上浆性能的影响[J].棉纺织技术,2015,43(4):9-12.
YE Qiujuan, LI Manli, JIN Enqi, et al. Influence of acrylate monomer structure on grafted starch sizing property[J]. Cotton Textile Technology, 2015, 43(4):9-12.
[11] JIN E Q, LI M L, XI B J, et al. Effects of molecular structure of acrylates on sizing performance of allyl grafted starch[J]. Indian Journal of Fibre & Textile Research, 2015, 40: 437-446.
[12] 张朝辉,徐珍珍,李伟.季铵阳离子醚化-十二烯基琥珀酸酯化淀粉浆料的黏附性能[J].纺织学报,2018,39(12):67-71,77.
ZHANG Chaohui, XU Zhenzhen, LI Wei. Adhesion properties of quaternary ammonium cation-esterified dodecenylsuccinic anhydride-etherified starch size[J]. Journal of Textile Research, 2018, 39(12): 67-71, 77.
[13] RUBINSON K A, RUBINSON J F. Contemporary Instrumental Analysis[M]. Beijing: Science Press, 2003: 466-468, 484-485.
[14] KEMP W. Qualitative Organic Analysis: Spectrochemical Techniques[M]. 2nd ed. London: McGraw-Hill Book Company (UK) Limited, 1986: 49-51, 134-137.
[15] 李曼丽,金恩琪,连瑶瑶.羽毛蛋白接枝共聚物对涤/棉经纱的上浆性能[J].纺织学报,2017,38(5):75-79,85.
LI Manli, JIN Enqi, LIAN Yaoyao. Study on sizing properties of feather keratin-graft-poly(acrylic acid-co-methyl arylate) for polyester-cotton blended yarns[J]. Journal of Textile Research, 2017, 38(5): 75-79, 85.
[16] WANG Y J, NIE J Y, FANG W, et al. Sugar-based aggregation-induced emission luminogens: Design, structures, and applications[J]. Chemical Reviews, 2020, 120: 4534-4577.
[17] QIAO F H, KE J H, LIU Y L, et al. Cationic quaternized chitosan bioconjugates with aggregation-induced emission features for cell imaging[J]. Carbohydrate Polymers, 2020, 230: 115614.
[18] YU Z Y, WU Y S, LIAO Q, et al. Assembled microdisk lasers of perylenediimides[J]. Journal of the American Chemical Society, 2015, 137: 15105-15111.
[19] ROY B, NOGUCHI T, TSUCHIYA Y, et al. Molecular recognition directed supramolecular control over perylene-bisimide aggregation resulting in aggregation induced enhanced emission (AIEE) and induced chiral amplification[J]. Journal of Materials Chemistry C, 2015, 3(10): 2310-2318.

苝四甲酸标记PVA荧光浆料的制备及其性能

Preparation of fluorescent PTCA labeled PVA size and its properties

PDF

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 4

编辑推荐

Metrics

[1]	徐凯杨, 钱建华, 孙丽颖, 彭慧敏, 赵永芳. 氯化聚氯乙烯/聚乙烯醇缩丁醛酯共混膜的亲水改性[J]. 现代纺织技术, 2022, 30(4): 178-185.
[2]	赵为陶, 姚雪烽, 严艺, 张德锁, 林红, 陈宇岳. rGO/AgNPs/改性PVA柔性应变传感薄膜的制备及其性能[J]. 现代纺织技术, 2022, 30(4): 80-88.
[3]	王梦颖,张国庆,张顺花. 相变蜡/聚乙烯醇/水三元共混物的流变性能研究[J]. 现代纺织技术, 2021, 0(3): 78-83.
[4]	赵勇，田伟，祝成炎，张春娥，权利军，周慧慧. PLA/苎麻与PVA/苎麻复合材料的制备及其力学性能研究[J]. 现代纺织技术, 2017, 0(05): 1-6.