适用于中温上浆的浆料筛选及其浆纱性能

doi:10.19398/j.att.202205023

现代纺织技术 ›› 2022, Vol. 30 ›› Issue (6): 127-132.DOI: 10.19398/j.att.202205023

适用于中温上浆的浆料筛选及其浆纱性能

吴菊明, 高波, 朱博, 高卫东

江南大学纺织研究所,江苏无锡 214122

收稿日期:2022-05-12 出版日期:2022-11-10 网络出版日期:2022-11-16
通讯作者:高卫东,E-mail:gaowd3@163.com
作者简介:吴菊明(1997—),女,安徽铜陵人,硕士研究生,主要从事浆纱技术方面的研究。
基金资助:
江苏省自然科学基金青年项目(BK20200608)

Slurry screening suitable for medium temperature sizing and the sizing performance

WU Juming, GAO Bo, ZHU Bo, GAO Weidong

Textile Research Institute, Jiangnan University, Wuxi 214122, China

Received:2022-05-12 Published:2022-11-10 Online:2022-11-16

摘要/Abstract

摘要： 降低上浆温度是浆纱节能的重要途径。为了筛选出适合中温上浆的淀粉主浆料,本文研究了磷酸酯淀粉、醋酸酯淀粉及氧化淀粉的浆液及浆膜性能。并通过在不同浆液温度下进行上浆试验,分析比较各上浆温度下的浆纱性能,最后采用目标函数法分析得出适宜的中温上浆温度。结果表明:醋酸酯淀粉的浆液黏度随温度和保温时间变化的稳定性较好、比黏附力较高,浆膜各性能最优,且在中温条件上浆的各浆纱性能接近于高温上浆,故醋酸酯淀粉采用75 ℃中温上浆是可行的。

关键词: 中温上浆, 浆料, 浆液, 浆膜, 浆纱

Abstract: Reducing the sizing temperature is an important way to save energy for sizing. In order to screen out the main starch sizing suitable for medium temperature sizing, the sizing and sizing film properties of phosphate starch, acetate starch and oxidized starch were studied in this paper. And through the sizing test under different sizing temperature, the sizing performance of each sizing temperature was analyzed and compared, and finally the appropriate medium-temperature sizing temperature was obtained by the objective function method. The results show that the sizing viscosity of the acetate starch has better stability with temperature and holding time, higher specific adhesion, the best sizing film properties, and the sizing properties at medium temperature are close to those of high temperature sizing. Therefore, it is considered feasible to use 75 °C sizing of acetate starch.

Key words: medium temperature sizing, sizing agent, sizing fluid, sizing film, sizing yarn

中图分类号:

TS103.12

吴菊明, 高波, 朱博, 高卫东. 适用于中温上浆的浆料筛选及其浆纱性能[J]. 现代纺织技术, 2022, 30(6): 127-132.

WU Juming, GAO Bo, ZHU Bo, GAO Weidong. Slurry screening suitable for medium temperature sizing and the sizing performance[J]. Advanced Textile Technology, 2022, 30(6): 127-132.

参考文献

[1] 沈艳琴,杨树,武海良,等.浆纱用中低温水溶性淀粉浆料的研究进展[J].纺织学报,2019,40(6):143-152.
SHEN Yanqin, YANG Shu, WU Hailiang, et al. Research progress of medium and low temperature water-soluble starch sizing for sizing[J]. Journal of Textiles Research, 2019, 40(6): 143-152.
[2] 杨树.中温水溶醋酸酯淀粉浆料的制备及浆纱应用[D].西安:西安工程大学,2019.
YANG Shu. Preparation and Sizing Application of Medium-temperature Water-soluble Acetate Starch Size[D]. Xi'an: Xi'an Engineering University, 2019.
[3] 曹新伟,宋秦杰,朱博,等.冷水可溶性马铃薯淀粉的低温上浆性能[J].纺织学报,2018,39(3):79-85.
CAO Xinwei, SONG Qinjie, ZHU Bo, et al. The sizing property of cold water soluble potato starch at low temperature[J]. Journal of Textile Research, 2018, 39(3): 79-85.
[4] 张慧晴,沈艳琴,武海良.脂肪醇聚氧乙烯醚在中温上浆中的应用研究[J].现代纺织技术,2019,27(4):81-83.
ZHANG Huiqing, SHEN Yanqin, WU Hailiang. Application of fatty alcohol polyoxyethylene ether in medium temperature sizing[J]. Advanced Textile Technology, 2019,27(4):81-83.
[5] 朱苏康,高卫东.机织学[M].北京:中国纺织出版社,2008.
ZHU Sukang, GAO Weidong. Weaving[M]. Beijing: China Textile Press, 2008.
[6] 岳鹏飞,祁彬,姚一军,等.棉纤维表面非纤维素物质对浆液黏附力的影响[J].棉纺织技术,2021,49(7):25-28.
YUE Pengfei, QI Bin, YAO Yijun, et al. Influence of non-cellulose substances on the surface of cotton fibers on the adhesion of slurries[J]. Cotton Textile Technology, 2021, 49(7): 25-28.
[7] SHEN Y Q, YAO Y J, WANG Z L, et al. Hydroxypropy-lation reduces gelatinization temperature of corn starch for textile sizing[J]. Cellulose, 2021, 28(8): 5123-5134.
[8] 李媛,钱现.淀粉浆料的糊化特性研究[J].纺织科学与工程学报,2018,35(2):79-81,91.
LI Yuan, QIAN Xian. Study on the gelatinization characte-ristics of starch slurry[J]. Journal of Textile Science and Engineering, 2018, 35(2): 79-81, 91.
[9] 宋秦杰,曹新伟,刘建立,等.GCWS玉米淀粉在棉纱低温上浆中的应用[J].棉纺织技术,2017,45(4):5-9.
SONG Qinjie, CAO Xinwei, LIU Jianli, et al. Application of GCWS corn starch in low temperature sizing of cotton yarn[J]. Cotton Textile Technology, 2017, 45(4): 5-9.
[10] 范雪荣,荣瑞萍,纪惠军.纺织浆料检测技术[M].北京:中国纺织出版社,2007:202-227.
FAN Xuerong, RONG Ruiping, JI Huijun. Textile Size Testing Technology[M]. Beijing: China Textile Press, 2007: 202-227.
[11] 赵其明.预湿对浆纱性能影响的研究[D].上海:东华大学,2006.
ZHAO Qiming. Research on the Effect of Pre-wetting on Sizing Performance[D]. Shanghai: Donghua University,
2006.
[12] 曹新伟.亚麻纱的碱-尿素体系改性及上浆性能研究[D].无锡:江南大学,2019.
CAO Xinwei. Study on the Modification and Sizing Performance of Linen Yarn by Alkali-urea System[D]. Wuxi: Jiangnan University, 2019.

[1]	龙柱, 李曼丽, 陆浩杰, 周赳, 王益峰. 苝四甲酸标记PVA荧光浆料的制备及其性能[J]. 现代纺织技术, 2022, 30(5): 174-180.
[2]	李双忠，吴明华. 双面数码活性印花工艺[J]. 现代纺织技术, 2020, 0(6): 92-95.
[3]	尹桂波，佟昀. 纯棉细特双色经剪花织物的设计与生产[J]. 现代纺织技术, 2020, 0(4): 37-41.
[4]	张慧晴，沈艳琴，武海良. 脂肪醇聚氧乙烯醚在中温上浆中的应用研究[J]. 现代纺织技术, 2019, 0(04): 81-83.
[5]	李媛,钱现. 淀粉浆液的黏附力研究[J]. 现代纺织技术, 2019, 0(02): 18-20.
[6]	吴保平，王秋霞. 气压传动技术在浆纱机上的应用[J]. 现代纺织技术, 2018, 0(06): 95-101.
[7]	王淼. 聚酯浆料与淀粉混合浆的性能测试及配伍研究[J]. 现代纺织技术, 2018, 0(04): 80-82.
[8]	张希文，沈艳琴，武海良，崔桂新，严燕钫. 乙醇胺对淀粉浆料增塑作用的研究[J]. 现代纺织技术, 2017, 0(06): 13-17.
[9]	杨明杰，沈艳琴，武海良，崔桂新，严燕钫. 取代度对醋酸酯淀粉结构与性能的影响[J]. 现代纺织技术, 2017, 0(04): 1-5.
[10]	王恒刚，曾勇. 纯棉高支高密品种无PVA上浆实践[J]. 现代纺织技术, 2015, 0(05): 55-57.
[11]	王恒刚. 9.8tex铜氨纤维色织面料的生产实践[J]. 现代纺织技术, 2015, 0(03): 55-56.
[12]	徐浩贻. 纯苎麻织物再生毛羽研究与对策[J]. 现代纺织技术, 2014, 0(06): 37-42.
[13]	徐浩贻. 特细号高密织物及其无PVA上浆研讨[J]. 现代纺织技术, 2014, 0(05): 47-50.
[14]	孙殿强,仇兆君. 细支高密牛仔布使用新型浆料无PVA上浆实践[J]. 现代纺织技术, 2014, 0(04): 18-19.
[15]	周长太. CD-DF333在特殊要求牛仔布上浆的应用[J]. 现代纺织技术, 2014, 0(04): 20-21.

适用于中温上浆的浆料筛选及其浆纱性能

Slurry screening suitable for medium temperature sizing and the sizing performance

PDF

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics